I’m dissapointed in my fly line’s life expectancy. I was on the water yesterday fishing a 7 wt and then threw my 3 wt for a bit. I noticed that the line I have spooled up for the 3 wt which is a SA 4 wt nymphing line is all cracked in many spots after 2 seasons.
I spend some time on the water each year, many people fish more than I do. Since Feb 10th I’ve enter 15 outtings into my log. That’s roughly 5 or 6 times a month on the water. I also fish more than this one rod for most of my outtings. Of the 10 outfits that I have the 7 and the 3 do the bulk of the work.
Someone mentioned that there were fly line companies that had a 5 year coating warranty. Air Flo maybe? If I had a line last 5 seasons that would be at the top of my list vs one that only lasts two seasons. I don’t have the receipt for that line any longer, but am dissapointed enough that I don’t wish to buy that same line again. It would be different if I stepped on it and cut it up or did something else stupid to it, but it deteriorating after just a couple seasons for a $60 line, I find it unacceptable.
So what is your experience with the life span of your fly line? By the way, I have a Teeny Fly line tool that I used with a cleaning solution to clean my lines. In other words I take the line off of the reel and clean the lines and recoat with a product made to clean fly lines. I maintain the lines and still have problems.
Sounds like you know how to care for a flyline. All I can say is buy a different brand and see how it goes. I have had good luck with my SA trout line and Rio Grand and selective trout models. The Rio Grand is a half line heavier than the # rating though.
My other buddy says he has trouble with the Rio selective trout tip floating, works fine for me.
Bob
I still use the original fly lines that came with most of my fly rod outfits. I’ve also purchased some additional lines like sinking tips and “big fly” lines. In ten years, I’ve never had a line crack. Most of my lines have been exposed to South Carolina heat in the trunk of my car too. That’s not to say that I haven’t damaged some fly lines but I tend to do that with my big feet and by not keeping my back cast upth (how do you spell that JC?). I’ve treated Orvis, Rio, SA and Cortland lines pretty tough and all have resisted cracking. I would complain to the manufacturer and see if you can’t get some satisfaction. 8T
Again, I have 10 outfits that I can fish from 3 to 10 wt. I’ve had two lines crack on me, this current SA and a Cortland. I’ll call SA on Monday to see what they say, but being a big company I am not too hopeful. These days I have been buying SA and Rio lines almost exclusively. If I’m not too lazy I will drag out the camera and shoot some shots and see what everyone thinks.
My buddy had that problem but he kept his fly equipment in his car. It does get hot in the summer in Oklahoma. He was buying 3 new lines(4wt,6wt,8wt) each year. He also fishes 250 to 300 days a year so he did use them a lot
The truth or me is, I have only had one line crack, at one place, right at the edge of the nail-knot. No other lines have ever cracked. Actually, none have ever worn out.
Hi Clay, I have had the same problem, but I am beginning to think it may be a case of a deffective line and not necessary a brand problem. I have a line with hair line stress cracks throughout. I started noticing this after about two and a half seasons of use. It was a Cortland 4wt 444 clear creek line. This was very disappointing to me since it was my best casting line. My trout season is just four months with really three good months of fishing. I used this line most often but took good care of it, cleaning and coating the line also. I have SA lines and a Rio line that seem to be holding out much better.
Do you do any lawn or road casting?
I had some Cortland crack years ago, went back to the shop I bought it from and they replaced it. Other than that, my Rio, SA and TT have held up great. I agree with one of the other posters. It could have been one from a defective lot.
The chances that these cracks are caused by a defect are near impossible. What do you think the odds are of 2 lines from 2 different companies cracking at the same time?? You have a better chance of winning powerball. It’s obviously something that you did. Insect repellent, sunscreen or any other possible chemicals that may have come into contact with the line?? Extreme heat or cold?? Stored in direct sunlight?? Whatever it is, it’s not a manufactures defect, but even so they will most likely replace it for you.
Insect repellent containing DEET is probably the worst thing you can get on a flyline, according to the late Leon Chandler, and I tend to agree. Sunlight is probably #2. If you store your line in the sunshine, you are gonna be disappointed with its life span.
I’m very much aware of the insect repellant issue and fly line coating. If I use repellant, and I don’t often, I apply it at the house and wash my hands before I go fishing.
On the two lines cracking, they did not happen at the same time. I also practice cast on the water and hardly ever lawn cast. Here is a shot of the Teeny line winder, now discontinued by the way, but it makes line maintenance easy. I also don’t store any of my rods or reels in a hot car.
Again this is the nymph line which has a subdued color for the first 30 feet and then the remainder of the line is brighter colored. Notice how the cracking is around the circumference of the line and is not cracked vertically.
To add to a prior post, I should also admit to casting a lot in the back yard (lawn) … like 4 or so evenings per week, minimum when it’s not freezing out.
I needed to overcome some issues (self taught) that were troubling. That and with a handful of bamboos, I like to play around. And I typically use bamboo’s as opposed to a handfull of Sages, mainly used for warmwater.
I started to have one of my SA lines begin to crack on me. It was 5 seasons old. I picked up the SA Line cleaner stuff and now my lines are back to feeling and looking brand new. I store em on the reel but out of the sunlight and in the house.
When you do lawn the cast the crap out of the line, does it look like the picture that I posted of my line or are the damages different? Just out of curiosity.
I was looking at the line again today and the area that is cracked is about the distance that I cast to often. The tip of the line doesn’t look like this. I am wondering if it happens when the line is bent at the tip of the rod? All good ideas so far from many others on possible reasons. Still haven’t called SA. Need to do that soon.
Hmmm, … I changed a SA Steelhead line in 2006 with the same cracks as in your photo Clay, … 'cept the line was more than 2 seasons old. I can’t remember how old it was, but it was several so it had +90 days of fishing.
